90 FR 53 pgs. 13105-13107 - Airworthiness Directives; Airbus Helicopters
Type: PRORULEVolume: 90Number: 53Pages: 13105 - 13107
Pages: 13105, 13106, 13107Docket number: [Docket No. FAA-2025-0352; Project Identifier MCAI-2023-00876-R]
FR document: [FR Doc. 2025-04543 Filed 3-19-25; 8:45 am]
Agency: Transportation Department
Sub Agency: Federal Aviation Administration
Official PDF Version: PDF Version
[top]
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2025-0352; Project Identifier MCAI-2023-00876-R]
RIN 2120-AA64
Airworthiness Directives; Airbus Helicopters
AGENCY:
Federal Aviation Administration (FAA), DOT.
ACTION:
Notice of proposed rulemaking (NPRM).
SUMMARY:
The FAA proposes to adopt a new airworthiness directive (AD) for all Airbus Helicopters Model EC225LP helicopters. This proposed AD was prompted by a determination that new or more restrictive airworthiness limitations are necessary. This proposed AD would require revising the airworthiness limitations section (ALS) of the existing maintenance manual (MM) or instructions for continued airworthiness (ICAs) and the existing approved maintenance or inspection program, as applicable, as specified in a European Union Aviation Safety Agency (EASA) AD, which is proposed for incorporation by reference. The FAA is proposing this AD to address the unsafe condition on these products.
DATES:
The FAA must receive comments on this NPRM by May 5, 2025.
ADDRESSES:
You may send comments, using the procedures found in 14 CFR 11.43 and 11.45, by any of the following methods:
• Federal eRulemaking Portal: Go to regulations.gov. Follow the instructions for submitting comments.
• Fax: (202) 493-2251.
• Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE, Washington, DC 20590.
• Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
AD Docket: You may examine the AD docket at regulations.gov under Docket No. FAA-2025-0352; or in person at Docket Operations between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this NPRM, the mandatory continuing airworthiness information (MCAI), any comments received, and other information. The street address for Docket Operations is listed above.
Material Incorporated by Reference:
• For EASA material identified in this proposed AD, contact EASA, Konrad-Adenauer-Ufer 3, 50668 Cologne, Germany; phone: +49 221 8999 000; email: ADs@easa.europa.eu; website: easa.europa.eu. You may find the EASA material on the EASA website at ad.easa.europa.eu.
• You may view this material at the FAA, Office of the Regional Counsel, Southwest Region, 10101 Hillwood Parkway, Room 6N 321, Fort Worth, TX 76177. For information on the availability of this material at the FAA, call (817) 222-5110. It is also available at regulations.gov under Docket No. FAA-2025-0352.
FOR FURTHER INFORMATION CONTACT:
Adam Hein, Aviation Safety Engineer, FAA, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; phone: (316) 946-4116; email: Adam.Hein@faa.gov.
SUPPLEMENTARY INFORMATION:
Comments Invited
The FAA invites you to send any written relevant data, views, or arguments about this proposal. Send your comments to an address listed under the ADDRESSES section. Include "Docket No. FAA-2025-0352; Project Identifier MCAI-2023-00876-R" at the beginning of your comments. The most helpful comments reference a specific portion of the proposal, explain the reason for any recommended change, and include supporting data. The FAA will consider all comments received by the closing date and may amend this proposal because of those comments.
Except for Confidential Business Information (CBI) as described in the following paragraph, and other information as described in 14 CFR 11.35, the FAA will post all comments received, without change, to regulations.gov , including any personal information you provide. The agency will also post a report summarizing each substantive verbal contact received about this NPRM.
Confidential Business Information
[top] CBI is commercial or financial information that is both customarily and actually treated as private by its owner. Under the Freedom of Information Act (FOIA) (5 U.S.C. 552), CBI is exempt from public disclosure. If your comments responsive to this NPRM contain commercial or financial information that is customarily treated as private, that you actually treat as private, and that is relevant or responsive to this NPRM, it is important that you clearly designate the submitted comments as CBI. Please mark each page of your submission containing CBI as "PROPIN." The FAA will treat such marked submissions as confidential under the FOIA, and they will not be placed in the public docket of this NPRM. Submissions containing CBI should be sent to Adam Hein, Aviation Safety Engineer, FAA, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; phone: (316) 946-4116; email: Adam.Hein@faa.gov. Any commentary that the FAA receives which is not specifically designated as CBI will be
Background
EASA, which is the Technical Agent for the Member States of the European Union, has issued EASA AD 2023-0141, dated July 14, 2023 (EASA AD 2023-0141) (also referred to as the MCAI), to correct an unsafe condition on Airbus Helicopters Model EC 225 LP helicopters. The MCAI states that new or more restrictive airworthiness limitations have been developed. EASA advises that airworthiness limitations and certification maintenance instructions are identified as mandatory for continued airworthiness and that Revision 14 of AH [Airbus Helicopters] EC 225 LP ALS, dated June 1, 2022, has been issued to specify all service life limits and maintenance tasks for EC 225 LP helicopters and separate the airworthiness limitations from the Master Servicing Manual (M.S.M.). The FAA is issuing this proposed AD to prevent a failure of critical parts and primary structural components, which if not addressed could result in loss of control of the helicopter.
The FAA is proposing this AD to address this unsafe condition. You may examine the MCAI in the AD docket at regulations.gov under Docket No. FAA-2025-0352.
Material Incorporated by Reference Under 1 CFR Part 51
The FAA reviewed EASA AD 2023-0141, which requires replacing components before exceeding their life limits and accomplishing all applicable maintenance tasks within thresholds and intervals specified in the ALS as defined in EASA AD 2023-0141. Depending on the results of the maintenance tasks, EASA AD 2023-0141 requires accomplishing corrective action(s) or contacting Airbus Helicopters for approved instructions and accomplishing those instructions.
Additionally, EASA AD 2023-0141 requires revising the Aircraft Maintenance Programme (AMP) by incorporating the limitations, tasks, and associated thresholds and intervals described in the specified ALS, as applicable. Revising the AMP constitutes terminating action for the requirement to record accomplishment of the actions of replacing components before exceeding their life limits and accomplishing maintenance tasks within thresholds and intervals specified in the applicable ALS as required by EASA AD 2023-0141 for demonstration of AD compliance on a continued basis.
This material is reasonably available because the interested parties have access to it through their normal course of business or by the means identified in the ADDRESSES section.
FAA's Determination
These products have been approved by the aviation authority of another country and are approved for operation in the United States. Pursuant to the FAA's bilateral agreement with this State of Design Authority, it has notified the FAA of the unsafe condition described in the MCAI and material referenced above. The FAA is issuing this NPRM after determining that the unsafe condition described previously is likely to exist or develop on other products of the same type design.
Proposed AD Requirements in This NPRM
This proposed AD would require the actions specified in EASA AD 2023-0141, described previously, as incorporated by reference, except for any differences identified as exceptions in the regulatory text of this proposed AD.
Explanation of Required Compliance Information
In the FAA's ongoing efforts to improve the efficiency of the AD process, the FAA developed a process to use some civil aviation authority (CAA) ADs as the primary source of information for compliance with requirements for corresponding FAA ADs. The FAA has been coordinating this process with manufacturers and CAAs. As a result, the FAA proposes to incorporate EASA AD 2023-0141 by reference in the FAA final rule. This proposed AD would, therefore, require compliance with EASA AD 2023-0141 in its entirety through that incorporation, except for any differences identified as exceptions in the regulatory text of this proposed AD. Using common terms that are the same as the heading of a particular section in EASA AD 2023-0141 does not mean that operators need comply only with that section. For example, where the AD requirement refers to "all required actions and compliance times," compliance with this AD requirement is not limited to the section titled "Required Action(s) and Compliance Time(s)" in EASA AD 2023-0141. Material referenced in EASA AD 2023-0141 for compliance will be available at regulations.gov under Docket No. FAA-2025-0352 after the FAA final rule is published.
Costs of Compliance
The FAA estimates that this AD, if adopted as proposed, would affect 29 helicopters of U.S. registry. Labor rates are estimated at $85 per work-hour. Based on these numbers, the FAA estimates the following costs to comply with this proposed AD.
Revising the ALS of the existing MM or ICAs and the existing approved maintenance or inspection program, as applicable, would take 1 work-hour, for an estimated cost of $85 per helicopter and $2,465 for the U.S. fleet.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority.
The FAA is issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701: General requirements. Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
The FAA determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this proposed regulation:
(1) Is not a "significant regulatory action" under Executive Order 12866,
(2) Would not affect intrastate aviation in Alaska, and
(3) Would not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
[top]
The Proposed Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:
PART 39-AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority:
49 U.S.C. 106(f), 40113, 44701.
§?39.13 [Amended]
2. The FAA amends §?39.13 by adding the following new airworthiness directive:
Airbus Helicopters: Docket No. FAA-2025-0352; Project Identifier MCAI-2023-00876-R.
(a) Comments Due Date
The FAA must receive comments on this airworthiness directive (AD) by May 5, 2025.
(b) Affected ADs
None.
(c) Applicability
This AD applies to Airbus Helicopters Model EC225LP helicopters, certificated in any category.
(d) Subject
Air Transport Association (ATA) of America Code 05, Time Limits/Maintenance Checks.
(e) Unsafe Condition
This AD was prompted by new and more restrictive airworthiness limitations. The FAA is issuing this AD to prevent failure of critical parts and primary structural components, which if not addressed, could result in loss of control of the helicopter.
(f) Compliance
Comply with this AD within the compliance times specified, unless already done.
(g) Required Action
Except as specified in paragraphs (h) and (i) of this AD: Comply with all required actions and compliance times specified in, and in accordance with, European Union Aviation Safety Agency AD 2023-0141, dated July 14, 2023 (EASA AD 2023-0141).
(h) Exceptions to EASA AD 2023-0141
(1) Where EASA AD 2023-0141 refers to its effective date, this AD requires using the effective date of this AD.
(2) This AD does not adopt paragraphs (1), (2), (4) and (5) of EASA AD 2023-0141.
(3) Where paragraph (3) of EASA AD 2023-0141 specifies "Within 12 months after the effective date of this AD, revise the approved AMP," this AD requires replacing that text with "Within 30 days after the effective date of this AD, revise the airworthiness limitations section of the existing maintenance manual or instructions for continued airworthiness and the existing approved maintenance or inspection program, as applicable."
(4) The initial compliance time for doing the tasks specified in paragraph (3) of EASA AD 2023-0141 is on or before the applicable "limitations" and "associated thresholds" as incorporated by the requirements of paragraph (3) of EASA AD 2023-0141 or within 30 days after the effective date of this AD, whichever occurs later.
(5) This AD does not adopt the "Remarks" section of EASA AD 2023-0141.
(i) Provisions for Alternative Actions and Intervals
After the action required by paragraph (g) of this AD has been done, no alternative actions and associated thresholds and intervals, including life limits, are allowed unless they are approved as specified in the provisions of the "Ref. Publications" section of EASA AD 2023-0141.
(j) Alternative Methods of Compliance (AMOCs)
(1) The Manager, International Validation Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the International Validation Branch, send it to the attention of the person identified in paragraph (k) of this AD. Information may be emailed to: AMOC@faa.gov.
(2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office.
(k) Additional Information
For more information about this AD, contact Adam Hein, Aviation Safety Engineer, FAA, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; phone: (316) 946-4116; email: Adam.Hein@faa.gov.
(l) Material Incorporated by Reference
(1) The Director of the Federal Register approved the incorporation by reference of the material listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.
(2) You must use this material as applicable to do the actions required by this AD, unless the AD specifies otherwise.
(i) European Union Aviation Safety Agency (EASA) AD 2023-0141, dated July 14, 2023.
(ii) [Reserved]
(3) For EASA material identified in this AD, contact EASA, Konrad-Adenauer-Ufer 3, 50668 Cologne, Germany; phone: +49 221 8999 000; email: ADs@easa.europa.eu; website: easa.europa.eu. You may find the EASA material on the EASA website at ad.easa.europa.eu.
(4) You may view this material at the FAA, Office of the Regional Counsel, Southwest Region, 10101 Hillwood Parkway, Room 6N-321, Fort Worth, TX 76177. For information on the availability of this material at the FAA, call (817) 222-5110.
(5) You may view this material at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, visit www.archives.gov/federal-register/cfr/ibr-locations or email fr.inspection@nara.gov.
Issued on March 13, 2025.
Steven W. Thompson,
Acting Deputy Director, Compliance & Airworthiness Division, Aircraft Certification Service.
[FR Doc. 2025-04543 Filed 3-19-25; 8:45 am]
BILLING CODE 4910-13-P